New insights into the application of microbial desalination cells for desalination and bioelectricity generation

Document Type: Research Paper

Authors

1 Department of Civil and Architectural Engineering, Sultan Qaboos University, P.O. Box 33, Al-Khoud, 123, Muscat, Sultanate of Oman.

2 Department of Petroleum and Chemical Engineering, Sultan Qaboos University, P.O. Box 33, Al-Khoud, 123, Muscat, Sultanate of Oman.

Abstract

Microbial desalination cell (MDC) is considered as a cost-effective substitution to the present energy-intensive desalination methods. Transfer of salt ions through ion exchange membranes towards the counter electrodes takes place through the utilization of self-generated bioelectricity and the concentration gradient. Ions transportation is one of the main challenges faced in MDCs to which less attention has been paid during the course of development. Therefore, new insights into the application of MDCs for efficient utilization of the generated bioelectricity for desalination are of high demand. In light of this, the present research thoroughly investigated the behavior of ions transportation and bioelectricity generation in three MDCs using three different salt solutions; NaCl, synthetic and artificial seawater. The findings obtained suggested that the efficiency of ions transportation and fouling behavior were influenced by salt compositions and concentration of the salt solution. Multivalent ions (i.e. Mg2+, Ca2+, and PO43-) were found more prone to precipitation on the CEM forming a scaling layer, whereas, inorganic deposition and biofouling development were more likely to happen on the AEM. This study also confirmed the occurrence of a significant back diffusion of K+ from catholyte into desalination chamber. Such back diffusion could limit the use of potassium buffer in catholyte in real-scale applications. Moreover, the coefficients of salt transfer and ion diffusion were calculated using mathematical model and Excel solver in three running MDCs. Low salt transfer and ion diffusion coefficients values obtained for all three MDCs could explain the general low performance of MDCs. Further studies are required to optimize the salt transfer and ion diffusion coefficients to boost MDC performance in general; affecting their real-scale implementation.

Graphical Abstract

New insights into the application of microbial desalination cells for desalination and bioelectricity generation

Highlights

  • Ion behavior of three different salt solutions was studied in identical microbial desalination cells (MDCs).
  • Mg2+, Ca2+, and PO43- were major ions resulting in scaling on cation exchange membrane.
  • Inorganic deposition and biofouling were more dominant on anion exchange membrane.
  • Back diffusion of K+ from catholyte to liquid under desalination reduced MDC performance.
  • Increasing bioelectricity generation will boost the rate of ions transportation.

Keywords


[1] Al-Mamun, A., Ahmad, W., Baawain, M.S., Khadem, M., Dhar, B.R., 2018. A review of microbial desalination cell technology: Configurations, optimization and applications. J. Cleaner Prod. 183, 458-480.

[2] Al-Mamun, A., Baawain, M.S., 2015. Accumulation of intermediate denitrifying compounds inhibiting biological denitrification on cathode in Microbial Fuel Cell. J. Environ. Health Sci. Eng. 13(1), 81.

[3] Al-Mamun, A., Baawain, M.S., Egger, F., Al-Muhtaseb, A.a.H., Ng, H.Y., 2017a. Optimization of a baffled-reactor microbial fuel cell using autotrophic denitrifying bio-cathode for removing nitrogen and recovering electrical energy. Biochem. Eng. J. 120, 93-102.

[4] Al-Mamun, A., Baawain, M.S., Dhar, B.R., Kim, I.S., 2017b. Improved recovery of bioenergy and osmotic water in an osmotic microbial fuel cell using micro-diffuser assisted marine aerobic biofilm on cathode. Biochem. Eng. J. 128, 235-242.

[5] Al-Mamun, A., Lefebvre, O., Baawain, M., Ng, H., 2016. A sandwiched denitrifying biocathode in a microbial fuel cell for electricity generation and waste minimization. Int. J. Environ. Sci. Technol. 13(4), 1055-1064.

[6] Al Lawati, M.J., Jafary, T., Baawain, M.S., Al-Mamun, A., 2019. A mini review on biofouling on air cathode of single chamber microbial fuel cell; prevention and mitigation strategies. Biocatal. Agric. Biotechnol. 101370.

[7] Al Sajwani, T.b.M.A., 1998. The desalination plants of Oman: past, present and future. Desalination. 120(1-2), 53-59.

[8] Al Suleimani, Z., Nair, V.R., 2000. Desalination by solar-powered reverse osmosis in a remote area of the Sultanate of Oman. Appl Energy. 65(1-4), 367-380.

[9] Baker, R.W., 2012. Membrane technology and applications. John Wiley & Sons.

[10] Barua, S., Zakaria, B.S., Al-Mamun, A., Dhar, B.R., 2018. Anodic performance of microbial electrolysis cells in response to ammonia nitrogen. Journal of Environmental Engineering and Science J. Environ. Eng. Sci. 14(1), 37-43.

[11] Barua, S., Zakaria, B.S., Chung, T., Hai, F.I., Haile, T., Al-Mamun, A., Dhar, B.R., 2019. Microbial electrolysis followed by chemical precipitation for effective nutrients recovery from digested sludge centrate in WWTPs. Chem. Eng. J. 361, 256-265.

[12] Chen, S., Luo, H., Hou, Y., Liu, G., Zhang, R., Qin, B., 2013. Comparison of the removal of monovalent and divalent cations in the microbial desalination cell. Front. Environ. Sci. Eng. 9(2), 317-323.

[13] Chen, X., Liang, P., Wei, Z., Zhang, X., Huang, X., 2012. Sustainable water desalination and electricity generation in a separator coupled stacked microbial desalination cell with buffer free electrolyte circulation. Bioresour. Technol. 119, 88-93.

[14] Choi, M.-J., Chae, K.-J., Ajayi, F.F., Kim, K.-Y., Yu, H.-W., Kim, C.-w., Kim, I.S., 2011. Effects of biofouling on ion transport through cation exchange membranes and microbial fuel cell performance. Bioresour. Technol. 102(1), 298-303.

[15] Cruz, C., Cisternas, L.A., Kraslawski, A., 2018. Scaling problems and control technologies in industrial operations: Technology Assessment. Sep. Purif. Technol. 207, 20-27.

[16] Davis, R.J., Kim, Y., Logan, B.E., 2013. Increasing desalination by mitigating anolyte ph imbalance using catholyte effluent addition in a multi-anode bench scale microbial desalination cell. ACS Sustainable Chem. Eng. 1(9), 1200-1206.

[17] Ebrahimi, A., Najafpour, G.D., Kebria, D.Y., 2018. Performance of microbial desalination cell for salt removal and energy generation using different catholyte solutions. Desalination. 432, 1-9.

[18] Elattar, A., Elmidaoui, A., Pismenskaia, N., Gavach, C., Pourcelly, G., 1998. Comparison of transport properties of monovalent anions through anion-exchange membranes. J. Membr. Sci. 143(1-2), 249-261.

[19] Elimelech, M., Phillip, W.A., 2011. The future of seawater desalination: energy, technology, and the environment. Science. 333(6043), 712-717.

[20] Forrestal, C., Xu, P., Ren, Z., 2012. Sustainable desalination using a microbial capacitive desalination cell. Energy Environ. Sci. 5(5), 7161-7167.

[21] Ghaffour, N., Bundschuh, J., Mahmoudi, H., Goosen, M.F., 2015. Renewable energy-driven desalination technologies: A comprehensive review on challenges and potential applications of integrated systems. Desalination. 356, 94-114.

[22] Goswami, A., Acharya, A., Pandey, A., 2001. Study of self-diffusion of monovalent and divalent cations in Nafion-117 ion-exchange membrane. J. Phys. Chem. B. 105(38), 9196-9201.

[23] Haavisto, J.M., Lakaniemi, A.-M., Puhakka, J.A., 2019. Storing of exoelectrogenic anolyte for efficient microbial fuel cell recovery. Environ. Technol. 40(11), 1467-1475.

[24] Hertel, T., Liu, J., 2019. Implications of water scarcity for economic growth, Economy-Wide Modeling of Water at Regional and Global Scales. Springer.

[25] Ho, W., Sirkar, K., 2012. Membrane handbook. Springer Science & Business Media.

[26] Jacobson, K.S., Drew, D.M., He, Z., 2011. Use of a liter-scale microbial desalination cell as a platform to study bioelectrochemical desalination with salt solution or artificial seawater. Environ. Sci. Technol. 45(10), 4652-4657.

[27] Jafary, T., Aljlil, S.A., Alam, J., Ghasemi, M., 2017. Effect of the membrane type and resistance load on the performance of the microbial fuel cell: a step ahead of microbial desalination cell establishment. J. Jpn. Inst. Energy. 96(9), 346-351.

[28] Jafary, T., Daud, W.R.W., Aljlil, S.A., Ismail, A.F., Al-Mamun, A., Baawain, M.S., Ghasemi, M., 2018. Simultaneous organics, sulphate and salt removal in a microbial desalination cell with an insight into microbial communities. Desalination. 445, 204-212.

[29] Kamcev, J., Paul, D.R., Manning, G.S., Freeman, B.D., 2018. Ion Diffusion Coefficients in Ion Exchange Membranes: Significance of Counterion Condensation. Macromolecules. 51(15), 5519-5529.

[30] Koók, L., Bakonyi, P., Harnisch, F., Kretzschmar, J., Chae, K.-J., Zhen, G., Kumar, G., Rózsenberszki, T., Tóth, G., Nemestóthy, N., 2019. Biofouling of membranes in microbial electrochemical technologies: Causes, characterization methods and mitigation strategies. Bioresour. Technol. 279, 327-338.

[31] Korngold, E., 1984. Electrodialysis—membranes and mass transport. Synthetic membrane processes, 191-220.

[32] Li, W.-W., Sheng, G.-P., Liu, X.-W., Yu, H.-Q., 2011. Recent advances in the separators for microbial fuel cells. Bioresour. Technol. 102(1), 244-252.

[33] Luo, H., Jenkins, P.E., Ren, Z., 2010. Concurrent desalination and hydrogen generation using microbial electrolysis and desalination cells. Environ. Sci. Technol. 45(1), 340-344.

[34] Luo, H., Xu, P., Jenkins, P.E., Ren, Z., 2012a. Ionic composition and transport mechanisms in microbial desalination cells. J. Membr. Sci. 409, 16-23.

[35] Luo, H., Xu, P., Ren, Z., 2012b. Long-term performance and characterization of microbial desalination cells in treating domestic wastewater. Bioresour. Technol. 120, 187-193.

[36] Luo, H., Xu, P., Roane, T.M., Jenkins, P.E., Ren, Z., 2012c. Microbial desalination cells for improved performance in wastewater treatment, electricity production, and desalination. Bioresour. Technol. 105, 60-66.

[37] Luo, T., Abdu, S., Wessling, M., 2018. Selectivity of ion exchange membranes: A review. J. Membr. Sci. 555, 429-454.

[38] Ma, D., Forrestal, C., Ji, M., Li, R., Ma, H., Ren, Z.J., 2015. Membrane configuration influences microbial capacitive desalination performance. Environ. Sci.: Water Res. Technol. 1(3), 348-354.

[39] Mikhaylin, S., Bazinet, L., 2016. Fouling on ion-exchange membranes: Classification, characterization and strategies of prevention and control. Adv. Colloid Interface Sci. 229, 34-56.

[40] Miller, S., Shemer, H., Semiat, R., 2015. Energy and environmental issues in desalination. Desalination. 366, 2-8.

[41] Nikhil, G., Yeruva, D.K., Mohan, S.V., Swamy, Y., 2016. Assessing potential cathodes for resource recovery through wastewater treatment and salinity removal using non-buffered microbial electrochemical systems. Bioresour. Technol. 215, 247-253.

[42] Peñate, B., García-Rodríguez, L., 2012. Current trends and future prospects in the design of seawater reverse osmosis desalination technology. Desalination. 284, 1-8.

[43] Ping, Q., Cohen, B., Dosoretz, C., He, Z., 2013. Long-term investigation of fouling of cation and anion exchange membranes in microbial desalination cells. Desalination. 325, 48-55.

[44] Ping, Q., Huang, Z., Dosoretz, C., He, Z., 2015. Integrated experimental investigation andmathematical modeling of brackish water desalination and wastewater treatment inmicrobial desalination cells. Water Res. 77, 13-23.

[45] Ping, Q., Porat, O., Dosoretz, C.G., He, Z., 2016. Bioelectricity inhibits back diffusion from the anolyte into the desalinated stream in microbial desalination cells. Water Res. 88, 266-273.

[46] Ping, Q., Zhang, C., Chen, X., Zhang, B., Huang, Z., He, Z., 2014. Mathematical model of dynamic behavior of microbial desalination cells for simultaneous wastewater treatment and water desalination. Environ. Sci. Technol. 48(21), 13010-13019.

[47] Post, J.W., Hamelers, H.V., Buisman, C.J., 2009. Influence of multivalent ions on power production from mixing salt and fresh water with a reverse electrodialysis system. J. Membr. Sci. 330(1-2), 65-72.

[48] Qu, Y., Feng, Y., Wang, X., Liu, J., Lv, J., He, W., Logan, B.E., 2012. Simultaneous water desalination and electricity generation in a microbial desalination cell with electrolyte recirculation for pH control. Bioresour. Technol. 106, 89-94.

[49] Sophocleous, M., 2004. Global and regional water availability and demand: prospects for the future. Nat. Resour. Res. 13(2), 61-75.

[50] Strathmann, H., 2004. Ion-exchange membrane separation processes. Elsevier.

[51] Wen, Q., Zhang, H., Chen, Z., Li, Y., Nan, J., Feng, Y., 2012. Using bacterial catalyst in the cathode of microbial desalination cell to improve wastewater treatment and desalination. Bioresour. Technol. 125, 108-113.

[52] Zhang, H., Wen, Q., An, Z., Chen, Z., Nan, J., 2016. Analysis of long-term performance and microbial community structure in bio-cathode microbial desalination cells. Environ. Sci. Pollut. Res. 23(6), 5931-5940.

[53] Zhao, N., Wang, H., He, Z., Yan, Q., 2019. Ammonia removal and recovery from diluted forward osmosis draw solution by using a tubular microbial desalination cell. Environ. Sci.: Water Res. Technol. 5(2), 224-230.

[54] Zuo, K., Liu, F., Ren, S., Zhang, X., Liang, P., Huang, X., 2016. A novel multi-stage microbial desalination cell for simultaneous desalination and enhanced organics and nitrogen removal from domestic wastewater. Environ. Sci.: Water Res. Technol. 2(5), 832-837.

[55] Zuo, K., Yuan, L., Wei, J., Liang, P., Huang, X., 2013. Competitive migration behaviors of multiple ions and their impacts on ion-exchange resin packed microbial desalination cell. Bioresour. Technol. 146, 637-642.